November 2020 RV Manufacturer Recalls

A manufacturer recall can create a safety risk if not repaired

Your recreational vehicle may be involved in a safety recall and may create a safety risk for you or your passengers. Safety defects must be repaired by a certified dealer at no cost to you. However, if left unrepaired, a potential safety defect in your vehicle could lead to injury or even death.

What is a recall?

When a manufacturer or the National Highway Traffic Safety Administration (NHTSA) determines that a recreational vehicle or item of RV equipment creates an unreasonable risk to safety or fails to meet minimum safety standards, the manufacturer is required to fix that vehicle or equipment at no cost to the consumer.

Pleasant Harbor RV Park, Lake Pleasant, Arizona © Rex Vogel, all rights reserved

NHTSA releases its most recent list of recalls each Monday.

It should be noted that RV recalls are related to vehicle safety and not product quality. NHTSA has no interest in an air conditioner failing to cool or slide out failing to extend or retract—unless they can be directly attributed to product safety.

NHTSA announced 13 recall notices during November 2020. These recalls involved 9 recreational vehicle manufacturers— Forest River (4 recalls), Lance Camper (2 recalls), REV (1 recall), Heartland (1 recall), Winnebago (1 recall), Jayco (1 recall), Keystone (1 recall), Thor Motor Coach (1 recall), and Triple E (1 recall).

Creekfire RV Resort, Savannah, Georgia © Rex Vogel, all rights reserved

Forest River

Forest River, Inc. (Forest River) is recalling certain 2021 Cardinal fifth wheel trailers. The fresh air intake sleeve for the furnace is too short and does not have proper connection of the furnace to the exterior, allowing furnace exhaust to enter the trailer.

Forest River will notify owners, and dealers will install the correct intake sleeve to allow for proper connection on the furnace, free of charge. The recall is expected to begin December 2, 2020. Owners may contact Forest River customer service at 1-574-296-7700. Forest River’s number for this recall is 15-1245.

Whispering Hills RV Park, Georgetown, Kentucky © Rex Vogel, all rights reserved

Forest River

Forest River, Inc. (Forest River) is recalling certain 2019-2021 Palomino trailers. The antenna wing may not be properly secured to the roof, allowing it to detach from the roof while moving.

Forest River will notify owners, and dealers will inspect, repair or replace the antenna, free of charge. The recall is expected to begin December 2, 2020. Owners may contact Forest River customer service at 1-269-432-3271. Forest River’s number for this recall is 400-1243.

Cajun Palms RV Resort, Henderson, Louisiana © Rex Vogel, all rights reserved

Forest River

Forest River, Inc. (Forest River) is recalling certain 2019-2021 Cherokee recreational trailers. The shore cord inlet wiring insulation may not have been sufficiently stripped back, causing a poor connection with the set screw.

Forest River will notify owners, and dealers will remove the inlet, and rewire or replace the inlet completely if necessary, free of charge. The recall is expected to begin December 2, 2020. Owners may contact Forest River customer service at 1-260-499-2100. Forest River’s number for this recall is 17D-1201.

Buccaneer State Park, Mississippi © Rex Vogel, all rights reserved

Forest River

Forest River, Inc. (Forest River) is recalling certain 2019-2020 Rockport work trucks. The battery box installed on these vehicles may be inadequately welded, and could detach.

Forest River will notify owners, and dealers will ensure the battery boxes are properly welded, free of charge. The recall is expected to begin December 16, 2020. Owners may contact Forest River customer service at 1-574-522-7599. Forest River’s number for this recall is 29-1252.

Hacienda RV Resort, La Cruces, New Mexico © Rex Vogel, all rights reserved

Lance Camper

Lance Camper Manufacturing. Corp. (Lance Camper) is recalling certain 2018-2021 Lance Camper trailers (models 855S, 850, 960, 975, 995, 1062, and 1172) equipped with a Dometic propane gas stove, model R1731 or R2131 manufactured November 2018 or later or model S31 manufactured November 2018 or later. In certain stove serial number ranges, a gas leak may occur in the cooking stove.

Lance Camper will notify owners, and Dometic dealers will repair the affected stoves. The recall is expected to begin December 7, 2020. Owners may contact Lance Camper customer service at 1-661-949-3322.

7 Feathers Casino RV Resort, Canyonville, Oregon © Rex Vogel, all rights reserved

Lance Camper

Lance Camper Manufacturing. Corp. (Lance Camper) is recalling certain 2018-2021 Lance trailers (models 1995, 2185, 2285, 1475, 1575, 1685, 1985, 2295, 2375, 2445, and 2465) equipped with a Dometic propane gas stove, model R1731 or R2131 manufactured November 2018 or later or model S31 manufactured November 2018 or later. In certain stove serial number ranges, a gas leak may occur in the cooking stove.

Lance Camper will notify owners, and Dometic will repair the stoves, free of charge. The recall is expected to begin December 7, 2020. Owners may contact Lance Camper customer service at 1-661-949-3322.

New Green Acres RV Park, Walterboro, South Carolina © Rex Vogel, all rights reserved

REV

REV Recreation Group (REV) is recalling certain 2020-2021 Fleetwood Flair, Bounder, Southwind and Fortis and Holiday Rambler Vacationer, Invicta, and Admiral motorhomes equipped with a Dometic propane gas stove, model R1731 or R2131 manufactured November 2018 or later or model S31 manufactured November 2018 or later. In certain stove serial number ranges, a gas leak may occur in the cooking stove.

REV will notify owners, and Dometic dealers will repair the affected stoves, free of charge. The recall is expected to begin December 4, 2020. Owners may contact REV customer service at 1-800-509-3417.

Goose Island State Park, Texas © Rex Vogel, all rights reserved

Heartland

Heartland Recreational Vehicles, LLC (Heartland) is recalling certain 2019-2020 Milestone fifth-wheel trailers. The outriggers may bend due to loading within the rear storage area.

Heartland will notify owners, and dealers will reinforce the frame, free of charge. The recall is expected to begin December 18, 2020. Owners may contact Heartland customer service at 1-877-262-8032.

Arizona Oasis RV Resort, Ehrenburg, Arizona © Rex Vogel, all rights reserved

Winnebago

Winnebago Industries, Inc (Winnebago) is recalling certain 2012-2021 Era 170X vehicles. The weld nut was installed on the wrong side of the bracket where the shoulder belt attaches, reducing the retention strength of the seat belt.

Winnebago will notify owners, and dealers will coordinate the inspection of affected units and the installation of a serrated flange nut in the intended weld nut location, free of charge. The recall is expected to begin December 21, 2020. Owners may contact Winnebago customer service at 1-800-798-2002.

Capitol City RV Park, Montgomery, Alabama © Rex Vogel, all rights reserved

Jayco

Jayco, Inc. (Jayco) is recalling certain 2021 Vision, Emblem, Vision XL, Alante, Precept, and Precept Prestige recreational vehicles, equipped with a Power Bedlift System. The bedlift motor may fail due to internal gear failure, causing the overhead bunk bed to release from the stowed position.

Jayco will notify owners, and dealers will replace the bed motor, free of charge. The recall is expected to begin November 30, 2020. Owners may contact Jayco customer service at 1-617-776-0344. Jayco’s number for this recall is 9903525.

Sunshine Valley RV Resort, British Columbia © Rex Vogel, all rights reserved

Keystone

Keystone RV Company (Keystone) is recalling certain 2020-2021 Cougar trailers equipped with the Off the Grid (OTG) Solar package. The inverter may have been incorrectly wired, causing power to energize the shore power connection, when in use.

Keystone will notify owners, and dealers will test the function of the inverter and rewire it as needed, free of charge. Ther recall is expected to begin December 18, 2020. Owners may contact Keystone customer service at 1-866-425-4369. Keystone’s number for this recall is 20-389.

River Run RV Park, Bakersfield, California © Rex Vogel, all rights reserved

Thor Motor Coach

Thor Motor Coach (TMC) is recalling certain 2010-2011 Four Winds Montecito 38D, 38E, 40J, 42B, 42C motorhomes, equipped with an Iota ITS-50R transfer switch. The transfer switch may experience a heat related failure due to being exposed to high electrical loads when used in higher ambient temperatures.

TMC will notify owners, and dealers will replace the Iota ITS-50R transfer switch with a different brand of switch, free of charge. The recall is expected to begin January 3, 2021. Owners may contact TMC customer service at 1-877-855-2867. TMC’s number for this recall is RC000205.

Fort McDowell Regional Park, Arizona © Rex Vogel, all rights reserved

Triple E

Triple E Recreational Vehicles (Triple E) is recalling certain 2019-2020 Wonder W24FTB, W24RTB, and W24MB motorhomes. The Multiplex G9 electronic control center can fail if excessive voltage is applied.

Triple E will notify owners, and dealers will install a protection module on the G9 system, free of charge. The recall is expected to begin in November 2020. Owners may contact Triple E customer service at 1-800-447-0343. Triple E’s number for this recall is CA#9830-1.

Please Note: This is the 22nd in a series of posts relating to RV Manufacturers Recalls

Worth Pondering…

It is easier to do a job right than to explain why you didn’t.

—Martin Van Buren